0
Firstly check there is power to pump.....I think it is not uncommon to have lost power through the ECU
or the pump relay. Before you decide to drop tank, be aware that a faulty pump may not be the problem. Use small slide on connectors if testing with active(+ve) and neg (-ve) 12V...
I am not sure that the pump neg. goes directly to ground...no circuitry to hand ...both may be switched at ECU. From memory the blue wire at top of tank is the +Ve. If both are switched looking for power at the plug/socket will be ineffective because you'll likely use a lamp for that and there could be pos. but no neg. or conversely .....or neither. You'll need a multimeter volt meter/ohm-meter. One I have here of untested condition and out of the vehicle measures 3.6 ohms across the plug.
If on hoist loosen front bolts almost to end then drop the rear of the tank. You can get to it that way. If tank is damaged at rear end the pump/bracket may have been damaged. The other way...drain tank, disconnect two rubber lines and locking fuel line at front of tank. Disconnect plugs at rear including fuel gauge (side towards rear) drop tank right out. Keep all fuel lines clean and check for dirt or other obstructions in lines on tank whilst out of car...(compressed air will do)
Repair tank if required after removing pump and perhaps other gear if necessary. Don't puncture tank and do check pump is not bottoming on tank. Do a check that pump operates through socket before refitting tanl. Don't burn or damage the pins doing that! Replace tank..reconnect. Then hope for the best.
Add your answer:
Earn +20 pts
Where is the fuel pump relay on Mitsubishi express express sj?
remove glovebox.
How to remove the fuel pump in a 1995 Mitsubishi montero?
You must remove the fuel tank to gain access to the fuel pump.
Is there a fuel pump fuse for a 03 mitsubishi express van?
Yes, under the hood.
Where is the fuel pump in a 1987 Mitsubishi Truck?
where is the fuel pump in a 1987 Mitsubishi Truck
Where is the fuel pump located and how do you remove it on a 1998 mitsubishi montero support?
Mounted on top and inside the fuel tank. Look for an access panel above the fuel pump. If there is none you must remove the fuel tank in order to gain access to the pump.
Where is fuel pump on a 1995 Mitsubishi eclipse?
The fuel pump is located inside the gas tank remove back seat to find access panel
Where is the fuel filter located on a 2002 Mitsubishi Lancer?
The fuel filter is located WITH the fuel pump AKA fuel module is what Mitsubishi calls this bundle, to access remove rear seats where you will find the cover to the assembly. The Fuel pump and Fuel Filter are intergrated to each other to save weight.
Where is the fuel pump located on a 1994 Mitsubishi Diamante SOHC?
The fuel pump is located in the fuel tank. Fortunately there is an access panel under the rear seat. Once you remove the rear seat, the pump is fairly easy to get to.
Where is the fuel pump on a 1994 Mitsubishi mirage?
The fuel pump on a 1994 Mitsubishi Mirage is located inside the fuel tank. Its placement allows it to push fuel toward the engine in a more efficient manner.
Where is the fuel pump for a 1994 Mitsubishi Galant?
The fuel pump is in the gas tank
Where is the fuel pump located on a 99 Mitsubishi Galant ls?
fuel pump is located in gas tank, but there is an access panel located under rear bottom back seat,remove access panel , and you can change fuel pump,.
Where is the fuel pump located on a 2003 Mitsubishi Galant?
Most likely located in fuel tank
